Ford F-150 (2004-2008) :: Vibration When Braking / Truck Almost Flutters In The Front End
Oct 10, 2012
I recently purchased a used 2006 Ford F-150 (5.4l RWD). I was fully aware of a problem with the brake rotors when I bought the truck from a dealership. They supposedly changed the rotors and the rotors appear to be new...But every time I brake the truck almost flutters in the front end. I haven't noticed vibration while on the highway, only when braking. I am worried because I can fix it I just cant seem to figure out what the problem is.
View 4 Replies
Advertisement
I'm having a problem with my 2010 F150 4x4. I'm a mail carrier and when I'm stopped at mail boxes my truck flutters and and acts like it's not getting gas or not getting fire. If I give it gas it goes on. It may do this 1 time a day or 100 times a day. My check engine light has come on and then after awhile it will go off. The Ford dealership thinks it is an oil pressure problem but the oil pressure gauge doesn't drop when this happens.
View 9 Replies
I'm having an issue with my 2005 f150 xlt. Its been happening for almost near a month and still cant locate the issue .
It has a vibration at 75km throughout the whole truck. Ive tried multiple things done to it by a mechanic, such as having the tires balanced and the ujoints replaced. The problem still persisted and after attempting to test out to see if press/releasing the parking break (my mechani suggested trying that out), my driveshaft fell off.
Apparently the center bearing snapped and cant simply be replaced on the 05's. So i had to get a new driveshaft installed (used, both the 3 mechanics I've gone to say its in good condition).
Even after replacing the driveshaft the issue persists - however it seems a bit softer than it was (I am guessing the old driveshaft was worn from the vibration causing it to be worse). After that I took it to another shop to see if they could locate the issue. They did a driveline inspection and engine inspection too see if a misfire could be the cause.
Again, nothing was found. The only thing they were able to find was that the issue only happens under load and slightly occurs at 40 and 100km as well (although alot softer then the one at 75) and they say they cant find anything physically and it was a mystery to them.
View 2 Replies
I took it to the dealer and they blamed the trailer. I told them that I have pulled two different trailers and it did it with both. Then he said that the trailer was not heavy enough to weigh down the springs. So now I not suppose to tow an empty trailer? Also my father in law has pulled the trailer with his Z71 with no shake and the other belongs to a neighbor with a 98 F150 with no shake. The vibration only starts above 45mph. Any clue as to what could be causing this?
View 14 Replies
My F-150 has developed a rattle and vibration at idle that only occurs with the truck in gear and stopped (with the brake depressed.) The noise appears to be coming from the front of the truck, perhaps from the driver's side (though it's difficult to tell while sitting in the cab).
Before I go crawling around underneath with my son holding the brake while the truck is in drive--I would sure like to know where it might be best to point the flashlight.
View 6 Replies
I have a 2007 ford f150 supercrew. I have a vibration in the front end at around 55mph. Doesn't vibrate at lower speeds or when you get above 60 mph. I have replaced the struts and just put new Michelin tires on it. Wheel bearings feel fine and front end bushings, tie rods and control arms look fine to me. It feels like the vibration is coming from the left side. I read somewhere that a possible cause is an upper control arm.
View 5 Replies
2008 2wd 4.6L 98K miles F150 for the past few weeks has been humming with a rhythmic vibration which feels like it is coming from driver's side front wheel. It doesn't do it constantly, nor at all speeds. Once I hit about 25mph, you can start to hear a humming. At 35, slight vibration. Between 50-60, heavier vibration. Sometimes at 65+, it subsides quite a bit. Both front rotor assemblies are newer, and I put in a brand new left because I thought it was a bad bearing.
View 5 Replies
I'm having trouble finding the source of a vibration in the front end if my 1999 f350 super duty 4x4. The vibration is felt all the time but worse when under 40mph, while braking, and especially when turning.
I have replaced the rotors and brakes, tie rods and Drag links since the issue started but no change. In the vibration. What should I check next?
View 4 Replies
I get a pretty severe vibration from the front suspension when braking. Here's what's been replaced:
Rotors
Brake pads
Steering coupler
Where do I go next? LCA/ball joints? Tie rods?
View 8 Replies
My 79 Lincoln Town Car vibrates in the front end during hard braking and braking from more than 30-35mph. There is no vibration in the rear, during turning or felt in the wheel. Is this wheel bearings, rotors, steering linkage, tire belts slipping or suspension? She has four wheel disc with early version of anti lock on rear. Brake fluid level is good with no leakage. Tires are near new but sat for long time parked in garage.
View 1 Replies
I replaced my tires yesterday with Bridgestone Turanza ER33 (245/45/19).
After replacing the tires, there is is an extreme vibration in the front end of the car when braking at highway speeds (60+ mph). Braking at sub 50mph speeds is completely normal. No lights, no vibration while driving. What could be the reason?
Also while removing the lug nut locks, the locks key broke apart (the black piece came out of the key). After like 45mins of trying, finally we got the locks out. I threw them away.
I searched online for regular lug nuts, but couldn't find any beside ebay. The local dealer says I need to wait for 3 weeks to get them from Japan! Where can I get a set of 4 regular lug nuts online?
I'm now running on 4 lug nuts on each wheel. Could this cause a problem? Could the vibration be caused by not having a 5th lug nut in place?
View 14 Replies
recently acquired an 07 mercury metallic with 118000 one owner and about 8 pages of maintenance all done at Lexus. car is in fantastic shape new tires, and brakes the interior still looks and feels brand new, to date I have changed the oil full synthetic 0W 20, eng and cabin air filters Toyota serviced the transmission changed the plugs with OEM off ebay. Rotated tires, rear diff fluid i couldnt find 75 / 85 anywhere so it wasn't too expensive from Toyota. the front left low beam was flickering so I replaced them I followed cucusdad instructions and it went as he mentioned about an hour per side, although I did take the opportunity to clean the inner fender well and the inside of the tires and rims.T hrough the years we have owned countless cars a couple of brand new ones although this is the first Lexus, I am very handy in the garage and have an understanding of electronics and maintenance upon reading this forum I think folks perhaps want perfect that's impossible as for mentioned this vehicle has been well maintained and obviously personally cared for.
: passanger seat heater/cool inop no light, (wifes only complaint, believe me that's saying a lot)
: aux audio input has intermediate static
: passanger rear door puddle light inop.
: slightly yellowed headlights.
: occasional vibration feels to be from front left while braking although mostly tracks straight ahead
: a very quiet car although I have read and may someday entertain some wind noise application on the triangle piece
None of these anywhere unreasonable on any car with similar miles and production date regardless the manufacture
View 8 Replies
I have a 2004 Honda Accord EX (4 cyl) with 102k miles. I bought it brand new and kept it completely in shape with regular service. For the past few months I start getting front end vibration at braking, mostly when slowing from high speeds and without any repair this vibration has now became common at all speed.... my diagnosis - I need to replace to turn disk/rotors....
While I have not remedy the rotor issue yet, I started getting this new vibration at 60 to 80 mph.... Below and above this range of speed i have no vibrations - the car will drive fine. This type of vibration in my experience for front wheel drives is mostly due to balancing or bad tires. so i took the easy way ..... and as i already needed tires well i dished out the dough and replaced all four with Michelin Primacy hoping that it will resolve the speed related vibration.... Well it did not?
I continue to drive as-is without addressing the real problem - coz I'm not sure what is causing the vibration.... now new additional vibration started on acceleration; any time I hit the gas pedal (normal acceleration or kick-down) I get vibration very similar to when a stick shift's gearbox required replacement/repair of the worn out pressure plate's (fingers/springs gets bent or weak) or the thrust bearing needs replacements/repair/grease packing. I'm from the old school stickshift transmission, my knowledge in automatic is very little - I have repaired Acura's automatic transmission before but I don't think repairing once will make me an expert in automatic.
So to summarize my issues or current state:
Issue# 1 front end vibration on braking
Issue# 2 front end vibration 60 to 80 mph speed only
Issue# 3 front end vibration on acceleration at all speed
The list above is in sequential order as I have experienced.
View 9 Replies
Fairly early (maybe 50k miles) my '04 Camry 4cyl began developing a vibration during braking that suggested a warped disk . It got progressively worse until it was very severe. So, even though the pads had plenty of life left, I changed the front rotors and pads at about 80k miles. This cleared up the vibration for a little more that 20k miles, but now at 105k miles on the car the braking vibration has returned. It's not bad yet but I can feel it progressing. Why would a warped disk problem return so soon after replacing both front rotors and pads to cure this very problem?
View 14 Replies
2008 F250 Crew Cab 5.4, 79K miles, had new brake pads installed at 40K miles. Recently, I noticed front end shudder and some pedal pulsation while braking. It started kind of sudden. My first thought was a warped rotor.
When I took things apart, I found passenger side front rotor was cracked and the caliper pistons were rusted and falling apart, the old pads were only worn about half way. My thoughts on a bad rotor were confirmed, and then some.
I replaced the broken caliper, both front rotors, installed new pads on all four wheels, and bled the brakes. To my surprise, the brake shuddering did not go away. I'm stumped.
View 10 Replies
2004 GC, 6 cyc, 2wd. Had TERRIBLE noise & vibration when braking but problem was intermittent, no codes generated. Everybody suspected ABS problem. New pads, new rotors, new ABS module no luck. Frequency increased but severity decreased. Technician finally experienced one occurrence, identified & replaced a weak steering stabilizer. Problem has surfaced again but not so severe and appears to be increasing in frequency.
My best description is when braking from 45-50 mph, Vibration & noise begins at about 35 mph, increasing in intensity until about 18-20 mph then stops. Seems to me that the transmission downshifts and the noise stops. AMCO suggested a cracked flywheel or loose bolts on the torch converter. Also the engine idles at 1100-1200 rpm on start-up then goes to 850 rpm - will not go lower. Does this sound like a transmission problem? The transmission was rebuilt/replaced at about 94,000 miles and the problem started at about 111,000 miles.
View 2 Replies
When I brake hard. My truck wants to veer right. It drives straight otherwise.
I recently had my front shock replaced and prior tp that my truck did the same thing, although it was much worse since my left front shock was leaking. Originally I thought it was pulling because of the bad shock but now that thet've been replaced I am not to sure.
Alignment issue or something else entirely? Coud bad rear shocks cause the issue?
View 14 Replies
It seems like I am going thru brakes I just replaced my brakes in May and my Rotors in July and when I brake my truck shakes like crazy. Is it the brakes again or am I missing something.
View 7 Replies
After my 2006 Ford F150 Lariet started shaking and pulsating when braking (38,000 miles) I took the truck to the Ford dealer and asked to have my brake pads checked. They came back and siad they looked fine and I had alot of wear left. Then I mentioned that is was shaking and asked them to check it again, they drove it and then said my rotors are warped and I need to replace the rotors and pads. I don't haul, tow or do anything crazy with it.
Now, here's my questions:
1. Can the rotors go bad and the brake pads be fine?
2. Should I go with a ceramic pad or stick with the OEM?
I'm just a female and don't want to be taken advantage of at the dealers. Cost is not an issue when purchasing a good product.
View 14 Replies
my truck has been acting kind of funny for the past 2 days. my RPM's are not as high as they usuaully are and my battery volt is 14.2 watts and when i hit the brakes and turn it drops down to 12.5. when that happens my battery light turns on, steering wheel tightens up and truck slows down. the only way to get my truck running after that is turning it off and starting it up again. What might be wrong or had the same problems?
View 3 Replies
I'm a new owner to my first 4x4 vehicle. My vehicle is a 2007 f150 xlt. Today while I was driving into work I had my vehicle in 4wd high. As I was going down hill I let off the gas and started braking. When all of a sudden my 4wd drive switched into neutral. I am wondering what could cause this to happen and whether it's an issue or not? It is snowing which was my purpose for being in 4wd.
View 9 Replies
