Ford 6.0L Power Stroke Diesel :: How To Remove Water Pump
Mar 29, 2015
I'm replacing my water pump and was wondering how to remove this.
View 3 Replies
Mar 29, 2015
Advertisement
Ford 6.7L Power Stroke Diesel :: 2013 - Water Pump Leaking?
2013 6.7..46k miles.
I know we have crappy radiators. that's why I bought the premiumcare plan. had that replaced at 45k..200 miles later smelling coolant. take it in they say the water pump is leaking from a "weap hole"...great...get it back..still smell coolant. very fricken frustrated. Not what I expect from a 45,000 dollar truck. especially a 2013....
Ford 6.0L Power Stroke Diesel :: 2004 - Hydrolock After Replacing Water Pump
I bought an '04 Powerstroke from a dealer in Dallas. Problems started to crop up immediately, so I replaced the thermostat. This seemed to handle my cooling issues for a couple days, until when preparing to drive to Austin, I noticed coolant pouring from what appeared to be the location of the water pump. I turned around and drove the two blocks back home, and replaced the water pump. However, when i went to restart the truck, I got only a partial turn of the crank. I let off immediately and waited a couple seconds, then tried again; same result.
I haven't had the glow plugs out yet to see what type of fluid is causing the lock. I was so pissed last night that I just went and took a nap, but I intend to check it out today after work. If it's fuel, excellent. I'll replace an injector and be done with it. If it's coolant, however, what are my most likely culprits? The EGR and oil coolers are stock, so maybe them. I would consider head gaskets, but that seems a little unlikely; while it was still running, there was no smoking, no notable pressurizing of the coolant system, etc. I am as of yet too unfamiliar with the underpinnings of the 6.0 to come up with any other possibilities, but I'm more than capable of dealing with them if you guys can suggest anything.
Ford 6.0L Power Stroke Diesel :: Bolt Size For Water Pump Pulley
Need to know the thread pitch and diameter for the water pump pulley bolts? The previous owner of the engine I bought clearly didn't know how to get the fan off as the pulley and plastic fan are both loose so I cannot loosen large nut.
View 1 RepliesFord 6.0L Power Stroke Diesel :: 2006 - Overheating - Water Pump Impeller Slipping?
have a 2006 f250 with the 6.0 Powerstroke diesel started overheating yesterday the ECT and EOTcheck fine with the scangauge always ran with in 8 degree's of each other. Thought maybe water pump impeller may have been slipping so it is new with no change. Fan kicks on like it should. Heater works good so don't think it is a thermostat.
View 13 RepliesFord 6.0L Power Stroke Diesel :: Water Pump Start Squeaking And Leaking On Cold Mornings
So I am on my 3rd water pump in 75k miles.
What I am assuming what was the original OEM pump died when the water pump pulley split in 2 and wrapped the belt around the pump at 187k.
The guy I use when I don't want to work on the beast put an O'rielly's lifetime new pump on it. That lasted almost 2 years and 40k miles.
I put another O'rielly's pump on it in the fall of 16' when it started leaking on cold mornings.
9k miles latter the last pump decided to start squeaking and leaking on cold mornings again!!
So I am now putting on a factory pump that should be made of gold for the price I paid for it from the local dealer. It was almost 2x's the cost of a new aftermarket pump.
My question to the collective is...is my experience with aftermarket pumps the norm?
Ford 6.7L Power Stroke Diesel :: 2011 F250 - Water In Fuel / Sighs Of Rust In High Pressure Pump?
Recently my 2011 F-250 Diesel with 21,000 miles seemed to start hard one morning. After starting the truck it ran well that day and started fine. The next morning it would not start. Had it taken to the dealer and they went to work. Started at the fuel filters and replaced low pressure fuel pump. Thought a piece of the defective pump had moved up fuel line. Removed high pressure pump and found signs of rust. All regular service intervals have been met. Didn't see this coming. No water in fuel light or other warning.
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: Water Pump Went Out?
My water pump went out. Besides the obvious replacing the pump is there anything else I should do while making the repair?
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: Water Pump Removal As A Unit
I have a 99 SD 7.3 with 210K miles. It has the OE water pump, clutch and fan. I am replacing every thing from pump to fan including pulley, thermostat and sensor. The question is can every thing be removed as a unit? I don't see why not but never did one that way.
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: F250 - Water Pump Replacement
How hard is the water pump to replace on 1999 f250 7.3 ...
Any thing special i need to know before tackling this job ...
Also is there any step by step instructions ???
Ford 6.7L Power Stroke Diesel :: Remove DEF System Only Without Tuning?
After all this time there's only a couple things about my 2012 6.7 I don't like, and one of them is the DEF system. I like the lack of smoke, and I REALLY like my warranty, but I don't like the acrid DEF exhaust smell and I don't like the amount of DEF fluid I'm going through.
So, looking for a kit to remove the DEF system but leave the truck otherwise untouched? I'd like to keep the DPF and not have to tune the truck, just eliminate the DEF and smell diesel fumes again.
I'm guessing this is a long shot given the amount of computer control of every aspect of the truck, but figured I'd ask anyway...
Ford 6.7L Power Stroke Diesel :: How To Remove Front Grill
Is there an easy How To write up on how to remove the front grill? I want to install some grill inserts I picked up.
View 7 RepliesFord 7.3L Power Stroke (1999-2003) :: 2001 F250 - No Start After Changing Water Pump
I have a 2001 F250 Super Duty V8 7.3 L. I removed the water-pump then waited five days for the oring for the new pump. I installed it and now the truck will not start. I have drained the fuel water separator and replaced the filter. On the passengers side through the kick panel I found that button popped out so I pushed it back in and still it will not run. It acts like its not getting fuel but if my fuel water separator is filing up I'm assuming mu fuel pump is working??
View 7 RepliesPassat (B5) :: 2003 - How To Remove Water Pump Pulley
How to remove the water pump pulley on a 2003 W8? I removed the 4 bolts but I don't want to go crazy and end up ruining it.
View 1 RepliesFord 6.7L Power Stroke Diesel :: How To Remove Chrome Piece Around The Cup Holders
How do you remove the chrome piece around the cup holders? I want to plasti-dip it so it quits shining in my eyes.
View 6 RepliesFord 6.0L Power Stroke Diesel :: 2006 - How To Remove Instrument Cluster
I've been searching for instructions/procedure on how to remove the instrument cluster on my 2006 6.0 Superduty. My odometer has been showing the classic signs of a cold solder joint, cutting in and out constantly. It's been doing this for a couple of years, and I've taken it to the dealership, since it's still under warranty, however they were not able to find the problem since they were not able to witness the lighting go off and on. I figured I'd just do it myself and not even bother with the dealership if I don't have to. I've read the threads on how to fix the issue, however, everything I've found is for 2004 or older models. Are there any threads specific to the 2006? Or, is the instrument cluster on the 2006 the same as another year model? Maybe I can find this info. there.
View 9 RepliesFord 7.3L Power Stroke (1999-2003) :: Thermostat Housing Broken Bolt - Replace Water Pump?
So I tried to replace my thermostat and housing and the housing bolt snapped off. Ok so I tried to extract that bolt off and the extractor bolt snapped off inside. I am guessing it might just be easiest to replace the water pump now? I am pretty much at the end of my mechanical rope which is short anyhow.
View 6 RepliesFord 7.3L Power Stroke (1999-2003) :: Water Pump Lower Elbow Bolts Torque Specs
I read 18lbs for the water pump but it took a cheater bar (perhaps due to corrosion) to get the water pump lower elbow bolts off.
On reinstallation, what should the lower elbow bolts be torqued to? Checked the sticky (Ziggy's Torque Specs) but didn't see the specs for this item.
Ford 7.3L Power Stroke (1999-2003) :: Starting To Leak Just Sitting In The Driveway - Water Pump Replacement
So the water pump on my early 99 (158k miles) is starting to leak just sitting in the driveway, did a little research last night and read a few write ups. Just wondering if any tips or tricks I could use to make this go easier. Also any list of parts I should replace and/or might need. I read on one write up about replacing it with an Airtex water pump and was wondering about what people thought of those, I would rather fix it right then just go with the cheapest parts. Possibly there are better brand water pumps out there?
View 5 RepliesCamry :: 2010 V6 SE - How To Remove Engine To Replace Water Pump
When the water pump goes bad do you have to remove the engine to replace it?
View 2 RepliesFord 6.7L Power Stroke Diesel :: Proper Way To Remove Driver Side Dash?
I'm sure I could start tugging on it and the clips would show themselves, but I'd rather not break any unseen clips or screw points. Is there a picture aided how-to for the removal of the drivers side of a dash on a 2012 f250? My tuner comes today and I'd prefer a clean install.
View 6 Replies