Ford Aerostar :: Loud Pop Coming From The Front Brakes
Oct 3, 2011
When braking from very low speed to full stop (f.e. parking maneuvers), i often hear a loud "pop" coming from the front brakes, regardless of steering direction. I'm pretty sure this has been discussed before here but can't find a thread.
Brakes are otherwise working good (front & rear) but it's time to do a maintenance just to be safe.
97' XLT RWD, 3.0L Vulcan, 99890miles - can't wait to see turning over to 100'000.. hope, i do not miss the moment
View 14 Replies
Advertisement
I get this loud click noise coming from the front end of my vehicle when I apply the brakes. It seems to happen much more often than not, especially at low speeds. I can only describe it as some sort of loud clicky clanky sound, it's also a single sound, it doesn't go on and on and it only happens when I apply the brakes.
View 2 Replies
Was driving issue free most of day, when leaving a red light I noticed my i had to give the van some extra gas to get up and go, then i could feel the brakes getting tighter and tighter to the point where I had to park the van. So currently my van is sitting in a parking lot 30 miles from home with locked up front brakes. Both driver and passenger front wheels were hot to the touch.
View 11 Replies
Recently, with below 0 temperatures. there have been a couple of times where my van has trouble starting. I would turn the key forward and here a loud knock coming from the starter solenoid and nothing else. but after a couple of tries, it will crank and start right up no problem. so i figured maybe it just has to do with cold weather? but today it wouldn't budge at all. I've been doing some research and came across the possibility that my engine has seized.
I realized that after replacing the radiator, i never checked my oil level since my engine was over-heating prior to the fix and when i checked it today i found that it is a quart low. I guess, what my question is what would be the issue? is my engine really seized or is it the starter or solenoid? could it be some other electrical issue? what are the steps i could take in finding the problem?
View 4 Replies
What would cause the front wheel on drivers side to lock up if it isn't the brakes. have been hearing a loud popping noise for a while on drivers side especially when turning left. Today got really loud just driving and then a real loud grinding noise. Then a loud pop and front wheel locked up and skidded across highway til i came to a stop. What it could be or how can i at least get wheel to turn to get it on trailer...
View 6 Replies
Just got a 2013 IS-F. Loving this car, but discovered an annoying issue. Grinding noise coming from front brakes when slowly coming to a stop below 5 mph. Is this normal?
View 9 Replies
My car is making some noise. The first problem is describing the noise. I think of it as similar to the sound one can make with a moist finger rubbing along the top of a wine glass. A passenger last night thought it sounded like those gadgets you whirl above your head to make noise. I think the noise is coming from the rear brakes. The noise goes away if I apply the brakes. It also goes away if I apply the emergency brake.
It doesn't always make the noise, but it is happening often enough, and is loud enough, that I had to switch from the news to loud music on today's drive to work. I have enough pad left on the brakes, but I don't know about the e-brake. I was under the impression that there are tiny drum brakes that are used as a mechanical emergency brake on these cars? I've never peeked inside. I do have 118k miles on the car.
Maintenance history available at [URL] .... where you can see that the rear rotors were cut at 78k. However, I can feel a ridge on the rotor which I think is where the rotor is swept by the pad. I wonder if this ridge is somehow a problem, maybe rubbing against something else (which will doubtlessly turn out to be now damaged and expensive).
View 4 Replies
I really enjoy my 2009 Smart car, excellent gas mileage, fun to drive too. The only drawback is all the dust coming off the front disc brakes that makes my front wheels look filthy even when the rest of the car is clean. Are there other brake pads that work as good as the factory originals yet don't give off so much dust?
View 4 Replies
The other day, I was coming home from work. After dropping off co worker, an old man pulled out infront of me. I applied the brakes. As car came to stop I heard a loud thump come from rear. Sounded like i was either bumped by a car, or maybe my entire rear end slid up 5 inches. But that's kinda what it was like. Then after the thump, I put my foot on gas pedal, and instead of car moving forward, the engine just revved. No movement, revved to like 3 grand. I let foot off gas pedal. And tried again. Car moved as normal. Then on the way home i attempted the same combo of rather quick brake and then gas. Same kinda thing happened. Not so hard of a thump. But noise from rear followed by the car no moving, just revving up till i stop and then try again. So even tho my story may suck n my explanation my suck more, whats going on? I just picked this wagon up. 01 glx 65k.
View 3 Replies
Replaced both rear calipers about 4 months ago, both were frozen. A few weeks ago I started getting some bad squeaking from the front brakes. The front calipers seemed fine when I did the rears.
Tonight I had even more fun with the beast. Drove to my sons baseball game and felt an odd "grinding" when braking. *Seems* to be coming from the front. On the way home, the grinding was worse and then the fun really started. Hit the brakes and the wheels started hopping enough to shake the whole friggin' truck. Leaving from a light, you could feel the brakes stick and then release, next stop was more shake n bake.
Not sure where to start on this one.
View 10 Replies
the other day i was driving with no music on my GS and i noticed every time i came to a complete stop, the brakes would produce a weird loud knock sound. it was rainning so i thought it would be from that... but then after driving it roughly 5-7miles the sound stopped... then since i noticed it, i hoped on my corolla to see if it had the same thing but no... only on my GS.. is this normal?
View 5 Replies
I leased a 2015 RC-350 F sport back in October. It is my 6th Lexus. I noticed that the brakes would repeatedly squeak (all types of conditions). It happens the final few feet while coming to a compete stop where the brakes would squeak incredibly loud. I had the car inspected at the dealership, and after my second complaint the car was inspected and a new set of rotors and pads were installed.
Unfortunately, the second set is worse than the first. Another complaint to the dealership and I was told they had done everything in their power, and I should complain to Lexus Customer Satisfaction. It's been 2 weeks since my initial call to them and finally after several calls to them asking for support they told me today it is deemed "normal operation of these high performance brakes".
View 6 Replies
1997 Limited SOHC auto.
I just replaced the transmission with a known good one from my XLT but the reverse doesn't work now and there is a loud banging coming from the front when I turn left or right.
It feels like the tyres are slipping on the road, like axle wind up. This happens in auto and 4wd high. What the banging is?
View 13 Replies
Driving in snow, braking in this car routinely handles poorly and brakes make a loud grinding sound. It sounds like the front brakes. I just had a brake job from a trusted dealer. I read the thread here on the Honda Accord that reported the same sort of brake problem. The issue is the brakes, NOT tires as that thread suggests. Braking strength is greatly impaired under these conditions. I am very apprehensive about driving in snow, and ready to trade in what is otherwise a fine car.
View 7 Replies
My 2003 windstar SEL needed new brakes and to have the rotors turned... instead I opted to buy new discs and pads online ... To my surprise the new discs were about a 16th of an inch thinner than the old.... I changed discs and pads and was happy for a few days, but now on occasion when coming to a stop the front brakes grind terribly....the next time i stop everything is fine...visa versa...dscs feel true (no pulsing) I DID APPLY BRAKE QUIET TO THE BACKS OF PADS....
View 2 Replies
I have a 06' Ranger 2WD with General Grabber tires that have about 30,000 miles on them and still show significant tread remaining.
Within the last 2 months, I have experienced excessive tire noise - like I am driving a Humvee or something. Also, when I turned right or left the tires would make even MORE noise - it seemed to be coming from the right front tire mostly. 2 weeks ago I had the tires rotated and the sound seems to have reduced while turning but I still have the howling Humvee noise while driving down the road. There is no vibration coming from the wheel, so I don't think it's a balancing issue. Could it be the bearings?
I also checked the PSI all around and one tire does have a slow leak but I try to keep to topped off.
View 1 Replies
I thought there was a v10 specific superduty section like how the psd does, but my thread went in the "performance, engine, troubleshooting" section.
I wanted more exposure than that particular small viewed area.
I don't have a video of the noise, but my 99 f450 v10 5spd has some iffy noise coming from the front. I've read so many threads on this and they either end with "my motor had 1-2-3 bad pistons" or "my flexplate was cracked" and all that dealt with chain tensioners were never finished.
I know what piston slap sounds like (worked on many cobras and lightnings with forged pistons that had it) and have experience with bad wrist pins and broken piston skirts, and this noise doesn't sound like any of it.
Noise is a loud clicking/clunking/Detroit diesel idle noise. When you rev the engine up it doesn't lighten or get better, only worse as rpm goes up. Oil is terrible looking, I'll be getting that changed this week.
Story on truck. I've had this thing for 4 years with blown motor. I got a buddy that acquired a parts truck and he said it ran good. I dropped my truck off and he swapped the engine. I got my truck back running, but with this engine noise. He said it needs to get run some more and change oil.
I think it's timing tensioners, my buddy says it will come out of it, a mechanic friend says it's going to blow up "because they all do" and I don't really want to replace the engine again.
If it's tensioners, how big of a job is it. I have the cam clamps and crank stop and the ford tools to make sure crank and cams don't rotate while apart.
I'm just 650 miles from my truck and may need someone else to do the work. Which sucks.
View 4 Replies
A while back I posted a thread trying to fix a clicking noise coming from the front end on my F-350 dually when applying the brakes at slow speeds (under 15 mph).
While returning from our camping trip last week the noise is back again. It does not occur after the truck sits overnight or for a few hours. But after driving for 30 minutes or longer the clicking will return when I apply the brakes at slow speeds. I tested the rotor temps with a heat gun and it seems to start when the rotor temps get above 120 degrees F. So I removed the brake pads & calipers, regreased the slide pins, cleaned up the pads and applied some lubricant on the back of the pads. I also bent the pad clips so they would fit snugger/tighter in the slots.
Whatever I did seemed to cure the clicking while driving around this weekend. I made sure I got the front brakes nice and warm - up to 180 degrees or so.
When I did this same procedure a few months ago the clicking went away - but eventually returned.
Should I get some better clips? Replace the sliding pins? Pads? The rotors & pads were replaced this winter & the shop said they and the labor are still under warranty. But if they use the same clips - I'm concerned I'll be back to square one in a month or so.
View 14 Replies
Fixing issues with my truck. I just ordered some latex surgical tubing and am getting ready to fix the rattling noise in my rear door by using the Epic's Door Seal Mod. Hopefully this will take care of that issue.
One more annoying noise though. Has there been any fixes to the buzzing window noise that is coming from the front passenger side. If the wind is blowing right and I'm running over 50mph, at times get a loud buzzing noise and really bugs me. Something is vibrating and at first i thought i had a speaker going out but found out that wasn't it.
I've called my dealer and informed them of this and asked if they've heard of this but of course they haven't and this usually means the won't do anything besides look for recalls or something. I have the noise recorded and scheduled an appointment with my Ford Dealer but again, they won't do anything most likely.
View 7 Replies
So my '01 E350 has been fine but tonight when I went to start it I didn't get a WTS light and the SES light was on and there was a weird number on my PHP Hydra that looked like r5 ? This happened a few times back to back so I tried starting it and it just cranked and cranked. Wtf? So I started pushing the button on the chip and all of the sudden I got the WTS light and the hydra flashed, now the chip was on tune 10 instead of 5 where it was when I parked it. I should also note that during these episodes there was a fairly loud clicking/clunking sound coming from the drivers front under the hood when I toggle the key on.. Sounds like maybe a relay? Louder than I recall ever hearing.
View 5 Replies
When I hit the brakes hard like seating the brakes the Aero would stall....
View 12 Replies
